Smart-power-systems LR Series Instrukcja Użytkownika

A.C. MODULAR GENERATOR SYSTEM OWNERS MANUAL MODEL#: LR-6.2 (60 Hz), LR-8 (60 Hz) and LR-6.2 (50 Hz)

Smart Power® Systems A. C. MODULAR GENERATOR SYSTEM Page 9 of 49 System Specifications MODEL OF GENERATOR LR-6.2 (60 Hz) LR-8 (60 Hz) LR-6.2 (50

Smart Power® Systems A. C. MODULAR GENERATOR SYSTEM Page 10 of 49 MODEL OF GENERATOR LR-6.2, LR-8 Fan Voltage Amperage 12 Inch Pushe

Smart Power® Systems A. C. MODULAR GENERATOR SYSTEM Page 11 of 49 Pre-Installation Guide Pre-Installation Check List WARNING: Never exceed 15

Smart Power® Systems A. C. MODULAR GENERATOR SYSTEM Page 12 of 49 2. SPS models LR-6.2 and LR-8 can be mounted on top of a vehicle,

Smart Power® Systems A. C. MODULAR GENERATOR SYSTEM Page 13 of 49 6" MINIMUM OBSTRUCTIONFREE CLEARANCE1" MAXIMUM SETBACK FROMFRONT OF C

Smart Power® Systems A. C. MODULAR GENERATOR SYSTEM Page 14 of 49 WARNING: Do not mount the tray assembly in any location that is not well venti

Smart Power® Systems A. C. MODULAR GENERATOR SYSTEM Page 15 of 49 Installation Guide 1. Refer to the Chelsea PTO Installation Instruction

Smart Power® Systems A. C. MODULAR GENERATOR SYSTEM Page 16 of 49 3. Mount the tray assembly as high as possible within the structure of the veh

Smart Power® Systems A. C. MODULAR GENERATOR SYSTEM Page 17 of 49 .208CLEARANCE HOLEFOR #10 SCREW4 PL.2.0003.3753.3751.6881.688 Hole pattern for

Smart Power® Systems A. C. MODULAR GENERATOR SYSTEM Page 18 of 49 Never install a 90° fitting at the pump outlet or inlet. Never use an inlet li

Smart Power® Systems A. C. MODULAR GENERATOR SYSTEM Page 1 of 49 Table of Contents Section Page Disclaimer ...

Smart Power® Systems A. C. MODULAR GENERATOR SYSTEM Page 19 of 49 for 50 Hz system only, the generator terminal strip should be configured as dep

Smart Power® Systems A. C. MODULAR GENERATOR SYSTEM Page 20 of 49 the system’s warranty. Replacement breakers must be obtained from Smart Power®

Smart Power® Systems A. C. MODULAR GENERATOR SYSTEM Page 21 of 49 The system controller has been designed to provide a purge option. With this o

Smart Power® Systems A. C. MODULAR GENERATOR SYSTEM Page 22 of 49 Enabling System Purge Option The purge option can also be set by performing th

Smart Power® Systems A. C. MODULAR GENERATOR SYSTEM Page 23 of 49 f. Check for hydraulic fluid leaks, all hose connections must be tight. Monit

Smart Power® Systems A. C. MODULAR GENERATOR SYSTEM Page 24 of 49 Step b: Hold Mode until Amps Line 1 Blinks 88. Release switch so 0Pt and AStr

Smart Power® Systems A. C. MODULAR GENERATOR SYSTEM Page 25 of 49 Example of Command & Control Center in normal mode Figure 13 2. The P

Smart Power® Systems A. C. MODULAR GENERATOR SYSTEM Page 26 of 49 4. If the system controller is powered on, but the generator is not

Smart Power® Systems A. C. MODULAR GENERATOR SYSTEM Page 27 of 49 b. When the Command & Control Center is in Normal mode, pressin

Smart Power® Systems A. C. MODULAR GENERATOR SYSTEM Page 28 of 49 8. If the system measures a hydraulic oil temperature that exceeds 175°F (79°C

Smart Power® Systems A. C. MODULAR GENERATOR SYSTEM Page 2 of 49 WARNING: Do not install or operate the A.C. modular generator system

Smart Power® Systems A. C. MODULAR GENERATOR SYSTEM Page 29 of 49 Step c: Press On/Off to answer “yes” and override the shutdown. Example of C

Smart Power® Systems A. C. MODULAR GENERATOR SYSTEM Page 30 of 49 a. From the Normal mode display, press Mode, as if you wanted to display the

Smart Power® Systems A. C. MODULAR GENERATOR SYSTEM Page 31 of 49 Step a: Press Mode to cause rvn and the y and n labels to appear. Step b: Pre

Smart Power® Systems A. C. MODULAR GENERATOR SYSTEM Page 32 of 49 Note: If you override the system and command it to operate with a

Smart Power® Systems A. C. MODULAR GENERATOR SYSTEM Page 33 of 49 Step c: Press On/Off to answer “yes” and override the shutdown. Example of C

Smart Power® Systems A. C. MODULAR GENERATOR SYSTEM Page 34 of 49 Message advising theoil is cold (less than40°F)Measured oiltemperature indegree

Smart Power® Systems A. C. MODULAR GENERATOR SYSTEM Page 35 of 49 g. If the hydraulic fluid appears dirty or black in the reservoir sight

Smart Power® Systems A. C. MODULAR GENERATOR SYSTEM Page 36 of 49 Time Since last Oil Filter Change in Hours. Press Mode until FLt and Xr are di

Smart Power® Systems A. C. MODULAR GENERATOR SYSTEM Page 37 of 49 a. Press the Mode switch repeatedly until one of the screens shown in Figure

Smart Power® Systems A. C. MODULAR GENERATOR SYSTEM Page 38 of 49 Troubleshooting Guide Diagnostic: The Command & Control Center will

Smart Power® Systems A. C. MODULAR GENERATOR SYSTEM Page 3 of 49 Never operate the system with leaks of any type. Clean up any hyd

Smart Power® Systems A. C. MODULAR GENERATOR SYSTEM Page 39 of 49 Diagnostic Faults: The following is a list of the diagnostic faults, with a br

Smart Power® Systems A. C. MODULAR GENERATOR SYSTEM Page 40 of 49 Hydraulic Problems: 1. Cavitation: Cavitation is caused by trying to p

Smart Power® Systems A. C. MODULAR GENERATOR SYSTEM Page 41 of 49 3. System Overheating: System overheating may be caused by re-circulation

Smart Power® Systems A. C. MODULAR GENERATOR SYSTEM Page 42 of 49 d. The stator field may be shorted or open. With a flashlight, check the gener

Smart Power® Systems A. C. MODULAR GENERATOR SYSTEM Page 43 of 49 h. The pump is faulty. If no faults are found in steps a. through g., the pro

Smart Power® Systems A. C. MODULAR GENERATOR SYSTEM Page 44 of 49 SPS Model Matrix PARENT P/NDESCRIPTIONCOMMAND & CONTROL CENTER

Smart Power® Systems A. C. MODULAR GENERATOR SYSTEM Page 45 of 49 Component Part Number Lists (Reference Figure 31 and Figure 32) ITEM NO. 1 2 3

Smart Power® Systems A. C. MODULAR GENERATOR SYSTEM Page 46 of 49 BOOST BLOCK OUTLET(1" HOSE TO PUMP INLET)VALVE INLET(5/8" HOSE FROM

Smart Power® Systems A. C. MODULAR GENERATOR SYSTEM Page 47 of 49 2LID LATCH(2 EA) 194THIS VIEW SHOWN WITH LID REMOVED113815101251476 LR-6.2 an

Smart Power® Systems A. C. MODULAR GENERATOR SYSTEM Page 48 of 49 Manufacturers Limited Warranty Smart Power® Systems Hydraulic Generator Cover

Smart Power® Systems A. C. MODULAR GENERATOR SYSTEM Page 4 of 49 Do not operate the system under electrical load with air in the hydraulic fluid

Smart Power® Systems A. C. MODULAR GENERATOR SYSTEM Page 49 of 49 5. The cost of airfreight or other extraordinary expenses for shipment of par

Smart Power® Systems A. C. MODULAR GENERATOR SYSTEM Page 5 of 49 Disclaimer Although SPS has taken all reasonable care to ensure that t

Smart Power® Systems A. C. MODULAR GENERATOR SYSTEM Page 6 of 49 Description of Product Hydraulic Generator Applications: This heavy-duty elect

Smart Power® Systems A. C. MODULAR GENERATOR SYSTEM Page 7 of 49 xyRESERVOIRPUMPPROPORTIONALVALVECASE DRAINMOTORCOOLERFILTERBOOST BLOCKVENTURI B

Smart Power® Systems A. C. MODULAR GENERATOR SYSTEM Page 8 of 49 Electrical schematic for LR-6.2 and LR-8 generator systems Figure 2